OMC Parts / Cobra Sterndrive Drawings+Video

Mercruiser Parts Repair Manual

T.C.Electronics / Marine Home Page
Electric clutch springs rebuilt
1971-1977 lower unit inspection procedure
1972-1985 Sterndrives (Remanufactured)
1986-1993 Sterndrives (Remanufactured)
1986 thru 1993 OMC upper gear case
400-800 Videos
Ball gear kit
Bearings and installation video
Bellows
Bolts, nuts, dowel pins
Carburetor kits
Couplers Chevy-Ford
Drive shafts
Electric shift repair cost
Engine water pumps
Engine gasket rebuilds
Exhaust housing
Fishing boating magazine sites
Fuel filter and water seperator
Fuel pumps
Gears
King Cobra parts
Love of boating
Manifolds
OMC used parts
Oil pump
Propeller shafts
Prop hardware 800 / 400 series
Thermostat housing
Seal kits
Shift cables
Starter solenoids
Steering information
Switch
Tilt motor
Tilt housing kits
Tools
Thermostats
Trim sender
Trim Solenoids
Tru-Course Steering
Tune up kits, points-rotor-condenser
U joints
Water pumps
OMC electric shift gear-head rebuild (prop shaft retainer)

Sample Table of Contents for Mercruiser Repair Manual

Mercruiser repair parts manual
Mercruiser repair parts manual

Click on picture for
Mercruiser outdrive parts

Seloc Mercruiser stern drives
1964 thru 1991
repair manual $43.29

BRAVO STERN DRIVE
  • U-Joint
  • Clutch
  • Bearing and Sleeve
  • Shifter Bushing
  • U-Joint Shaft
  • Driveshaft
  • Propeller Shaft Bearing
  • Driveshaft
  • Bearing Carrier
  • Drive gear and Bearing
  • Driveshaft Bearing Races
  • Drive Gear and Driveshaft
BRAVO LOWER UNIT
  • Shimming
  • Pinion Gear
  • Driveshaft Preload
TUNING
  • Ignition
  • Fuel System

BELL HOUSING
  • Gimbal Housing Ball Bearing
  • Transom Shift Cable
  • Exhaust Bellows
  • U-Joint Bellows
  • Bell Housing
  • Gimbal Ring
COOLING
  • In-Line Engines w/Std. Sys.
  • V8 Engines w/Std. Sys.
  • V8 Engines w/Closed Sys.
WATER PUMP
  • 470 Engine
  • Ford V8 Engines
  • GMC V8 Engines
STERN DRIVE WATER PUMP
  • Lower Unit
  • Pump
BRAVO WATER PUMP ON ENGINE
  • Cleaning
ELECTRICAL
CHARGING SYSTEM
  • Alternator
  • Regulator
ENGINE
  • Ignition System
  • Compression Test
EXHAUST MANIFOLD SERVICE
PISTON, RING
FUEL
FUEL PUMPS AND FILTERS
  • Single-Diaphragm Pump
  • Dual-Diaphragm Pump
  • Fuel Pump
  • Fuel Filter
  • Water Separating Filter
CARBURETORS
ROCHESTER
  • Adjusting
CARTER RBS
  • Description
ROCHESTER 2GC
  • Two-Barrel
ROCHESTER 4MV
  • Four-Barrel
HOLLEY CARBURETORS
  • Two-Barrel - 2300C
  • Four Barrel - 4150, 4160, & 4011
IGNITION
  • Ballast Resistor
TROUBLESHOOTING
  • Compression
  • Spark Plug
DISTRIBUTOR SERVICE
  • Delco-Remy
  • Mallory
  • Autolite
  • Prestolite
  • Point Gap
REMOTE CONTROLS
  • Bravo Shift Cable Service
  • Shift Cable
MERCRUISER STERN DRIVE
TRIM CYLINDER
  • U-Joint, Drive Gear and Bearing
  • Upper Gear Housing
  • Upper Driveshaft
  • Driven Gear
  • Bearing
  • Driven Gear Shimming
  • U-Joint Bearing
  • Drive Gear Shimming
LOWER UNIT
  • Reverse Bearing Carrier
  • Propeller Shaft
  • Forward Gear
  • Reverse Gear
  • Pinion Gear
  • Gear Shimming
  • Water Pump

T.C.Electronics/Marine order desk number (416) 751-7326
* 21 Canadian road unit 17* Toronto Ontario * Canada * M1R-5G2